Spacewalking astronaut copes with frayed tether, bad jetpack

In this image from video made available by NASA, astronaut Joe Acaba performs a spacewalk outside the International Space Station on Friday, Oct. 20, 2017. Acaba was barely outside an hour when he had to replace one of his safety tethers. Spacewalking astronauts always have more than one of these crucial lifelines in case one breaks. They also wear a jetpack in case all tethers fail and they need to fly back to the space station. (NASA via AP)
In this image from video made available by NASA, astronaut Joe Acaba performs a spacewalk outside the International Space Station on Friday, Oct. 20, 2017. The 250-mile-high complex is currently home to three Americans, two Russians and one Italian. (NASA via AP)
This still image provided by NASA shows astronaut Joe Acaba during a spacewalk at the International Space Station on Friday, Oct. 20, 2017. Commander Randy Bresnik floated accompanied by Acaba, teacher-turned-astronaut . Their main job is to replace a blurry camera on the new robotic hand that was installed by spacewalkers two weeks ago. (NASA via AP)

CAPE CANAVERAL, Fla. — A spacewalking astronaut successfully replaced a blurry camera outside the International Space Station on Friday, but had to contend with a balky jetpack and a frayed safety tether.

Both jetpacks and safety ties are crucial for saving a flyaway astronaut.

NASA said Joe Acaba was always securely attached to the orbiting outpost and never in any danger during the nearly seven-hour spacewalk.

But one of his tethers had to be replaced shortly after he and station commander Randy Bresnik floated outside. Mission Control noticed the red lifeline was frayed and worn. Bresnik went back to the air lock to get Acaba a spare.

Then five hours into the spacewalk, Mission Control saw that the right handle on Acaba's emergency jetpack was popped open — again. Bresnik once more went to his crewmate's assistance, even offering some tape to keep it down.

After consulting for several minutes in Houston, flight controllers declared the jetpack unreliable and ordered Acaba back inside, once he was done greasing the new robot arm on the space station's big robot arm. He finished the lube job, then headed in.

Bresnik acknowledged things didn't go as planned, "with all the stuff that happened today and the challenges we had." But he thanked everyone for their hard work and diligence.

In the end, only a couple minor chores were left undone.

"Great work today," Mission Control radioed as the spacewalk came to a close.

It was the third spacewalk in two weeks for U.S. astronauts. Bresnik went out on all three; he was accompanied by Mark Vande Hei to install the new robotic hand on Oct. 5 and lubricate it on Oct. 10.

Each spacewalker wears a jetpack for use in an emergency. It's available in case an astronaut's multiple tethers fail and allows the spacewalker to fly back to the station. It's been tested by orbiting astronauts — years ago — but never called into urgent action.

Earlier, Acaba provided necessary focus to the space station's robot arm.

He unbolted a blurry camera from the new robotic hand installed two weeks ago. He then popped in a spare, which flight controllers quickly tested from Houston. The replacement provided crisp, clear views.

Sharp focus is essential when the space station's robot hand grabs an arriving supply ship and anchors it. The next delivery is a few weeks away, prompting the quick camera swap-out.

Orbital ATK, one of NASA's commercial shippers, plans to launch a cargo ship from Virginia on Nov. 11.

Acaba and the station's commander, Randy Bresnik, were supposed to go spacewalking earlier this week. But NASA needed extra time to add the camera repair to their chores.

Friday's spacewalk — expected to be the last one for the year — also saw the astronauts installing a high-definition camera, replacing a fuse and removing thermal insulation from spare electronics. Early next year, astronauts will replace the hand on the opposite side of the 58-foot robot arm, Canada's main contribution to the space station. The original latching mechanisms are showing wear and tear since the arm's launch in 2001.

The 250-mile-high complex is currently home to three Americans, two Russians and one Italian.

A one-time high school and middle school teacher, Acaba is the first astronaut of Puerto Rican heritage; his parents were born there. He ventured out on Friday's spacewalk as the station soared above the hurricane-ravaged island, where much of his extended family lives.

"There's a whole line of people looking up and smiling today as you get ready to head out the door," Bresnik told him.

Must Read

Lawmaker issues subpoena to FBI for Clinton probe records

Sep 12, 2016

A top House Republican has escalated the GOP's battle with the FBI over the decision not to recommend criminal charges against Hillary Clinton for her use of a private email system by issuing a subpoena for the full case file from the investigation

Judge: Kim Dotcom can livestream legal fight against the US

Aug 30, 2016

A New Zealand judge on Tuesday decided to allow internet entrepreneur Kim Dotcom to livestream his latest legal bid to halt his extradition to the United States

Lawsuit targets searches of electronic devices at US border

Sep 13, 2017

A federal lawsuit filed Wednesday claims that the U.S. government's growing practice of searching laptops and cellphones at the border is unconstitutional because modern electronic devices carry troves of private personal and business information

People also read these

Lawmaker issues subpoena to FBI for Clinton probe records

Sep 12, 2016

A top House Republican has escalated the GOP's battle with the FBI over the decision not to recommend criminal charges against Hillary Clinton for her use of a private email system by issuing a subpoena for the full case file from the investigation

Judge: Kim Dotcom can livestream legal fight against the US

Aug 30, 2016

A New Zealand judge on Tuesday decided to allow internet entrepreneur Kim Dotcom to livestream his latest legal bid to halt his extradition to the United States

Lawsuit targets searches of electronic devices at US border

Sep 13, 2017

A federal lawsuit filed Wednesday claims that the U.S. government's growing practice of searching laptops and cellphones at the border is unconstitutional because modern electronic devices carry troves of private personal and business information